Water Tight Technologies

Water Garden Products
  Water Garden Family of Products
  Water Garden Creation
  RUBBERALL® Liner Membrane Qualities
  Product Specifications
  Safety Data Sheets
    RUBBERALL® membrane
   
      Seam Tape
      Tape Primer
      Membrane Cleaner
  Warranty

 

 

See Printer-Friendly Version
Download PDF File

SAFETY DATA SHEET

May be used to comply with OSHA's Hazard Communication Standard, 29CFR 1910.1200.

SECTION 1 - PRODUCT IDENTIFICATION

Product Name:
Seam Tape Primer Plus

24-Hour Emergency Telephone Number:
800-424-9300 CHEMTREC

Chemical Name/Synonyms:
Butyl Rubber Adhesive

Manufacturer's Name:
Water Tight Technologies, LLC

Chemical Family:
Mixture

Manufacturer's Address:
P.O. Box 899 Payson, AZ  85547

Chemical Formula:
Not Established

NFPA Acute Hazard Rating: 
Health 2, Flammability 3, Reactivity 0
HMIS Acute Hazard Rating:
Health 2, Flammability 3, Reactivity 0


SECTION 2 - CHEMICAL COMPOSITION

Hazardous Components (chemical names)
Heptane

 OSHA (1910. 1200)

Case No.
142-82-5    

OSHA STEL
TLV 500 PPM

PEL
500 ppm

ACGIH TLV
400 ppm

Toluene

 

108-88-3

Ceiling 300PPM

200 ppm

osha tlv 50PPM

Methyl Alcohol

 

67-56-1

ACGIH 250PPM

200 ppm 200 ppm

Nonhazardous as per 29
CFR 1910. 1200.

 

None

None Established


SECTION 3 - PHYSICAL & CHEMICAL CHARACTERISTICS

Appearance/Odor:
Thin clear liquid, aliphatic odor

Physical State:
Liquid

Solubility in Water:
Insoluble

Boiling Point:
151° – 284° F

Specific Gravity (HO=1):
0.793 (Water=1)

Melting Point:
N/A

Vapor Pressure:
36 mm Hg@ 20° C

Vapor Density (Air=1):
3.0-3.7

Freezing Point:
Not Established

Percent Volatiles:
83 %

Evaporation Rate:
Unknown

Reactivity in Water:
Not Established

pH (Full Strength):
Not Established

pH (Recommended Dilution):
Not Established

Refraction Index:
N/A


SECTION 4 - FIRE & EXPLOSION HAZARD DATA

Flash Point:
25° F TCC

Flammable Limits (in air):
LEL: 1.1%; UEL: 7%

Extinguishing Media:
Dry chemical, carbon dioxide, water fog or foam. Water should be used to keep fire exposed containers cool.

Fire Fighting Procedures:
Use water spray to cool adjacent surfaces and fire exposed containers. Protect against inhalation of combustion products.

Firefighters should wear full protective clothing including self-contained breathing apparatus to prevent inhalation of smoke and decomposition products. Toxic fumes and vapors may be involved.

Hazardous Decomposition Products:
Carbon Dioxide, Carbon Monoxide, acrid smoke and irritating fumes.

Special Fire & Explosion Hazards:
Flammable liquid. Vapors are heavier than air and can flow along surfaces to ignition sources and flash-back. Keep work areas free from open flames, sparks, hot metal surfaces and other sources of ignition. Ground objects prone to static electricity.

Method Used:
Estimate based on the flash point of the most volatile component.

Auto-Ignition Temperature:
Not Established


SECTION 5 - HEALTH HAZARD DATA

Permissible Exposure Limit:
Not Established

Signs and Symptoms of Exposure:
Eye contact may cause severe eye irritation, redness, tearing and blurred vision. Prolonged skin contact may cause irritation, dermatitis and drying of the skin. Other symptoms are dizziness, nausea or vomiting. Sensitive individuals may exhibit eye, nose, throat or dermal irritation with prolonged exposure to processing fumes or vapors. Inhalation may cause repiratory system irritation and central nervous system depression (Narcosis) fatigue. May cause unconsciousness if exposure is excessive. Brief (4 minutes) exposures to heptane at concentrations above 5000 ppm produce nausea, loss of appetite, and a gasoline-like taste that might persist hours after exposure.

Effects of Overexposure: Medical Conditions Aggravated by Exposure:
Medical Conditions Aggravated By Exposure.
Toxic fumes may be released during fire. Exposure to fumes may aggravate pre-existing eye, lung, and skin conditions.

Acute:
Irritation to eyes, lungs, and mucous membranes

Chemical Listed as a Carcinogen (or Potential Carcinogen):
National Toxicology Program:  NO
L.A.R.C. Monographs: NO
OSHA: NO

Chronic:
Excess exposure can cause CNS depression, headache, nausea, narcosis, and liver and kidney damage

Acute Oral LD50
>8 ML/KG (Rat)
Acute Dermal LD50
>4 ML/KG (Rat)                                                                    
Acute Inhalation LC50
3400 PPM/4H (Rat)

Emergency & First Aid Procedures:
Eye Contact: 
Hold eyes open and flush immediately with a gentle stream of water for at least 15 minutes, preferable at an eyewash fountain. Call physician
Skin Contact:
Clean with rubbing alcohol, followed immediately by washing affected area with soap and water.
Inhalation:
Remove to fresh uncontaminated air. Administer oxygen or artificial respiration, if necessary. Call physician.
Ingestion:
Consult a Physician. DO NOT INDUCE VOMITING
Primary Route of Entry:
Inhalation, skin absorption.


SECTION 6 - REACTIVITY DATA

Stability:
Stable at ambient temperatures and pressures

Incompatibility:
Strong oxidizers, acids, bases.

Hazardous Decomposition Products:
Partial combustion may release toxic gases or vapors, such as oxides of carbon and nitrogen along with traces of HCL.

Hazardous Polymerization:
N/A

Conditions to Avoid:
Open flames, sparks, and closed areas that restrict adequate ventilation.


SECTION 7 - SPILL OR LEAK PROCEDURES

Steps to be taken in case material is released or spilled:
Small spill:
Shut off and eliminate all ignition sources. Recover released product using inert materials such as sand, earth, or other suitable materials. Minimize skin contact. Use non-sparking tools. Ventilate confined spaces. Keep product clear of sewers, water, or extensive land areas. Assure conformity with applicable government regulations.  Transfer into secure containers for proper disposal. Avoid static electricity build-up by grounding a fixed equipment and transfer containers. Use personal protective equipment as outlined below.

Large Spill:
Same as small spill.

Waste Disposal Method:
Dispose of as a hazardous waste in accordance with EPA/RCRA regulations 40CFR261 21(a) (1) Ignitability: D001


SECTION 8 - SPECIAL PROTECTION

Respiratory Protection:
In areas with inadequate ventilation, the use of a NIOSH-Certified respiratory protection for organic vapor is recommended.

Eye Protection:
Impervious  glasses recommended

Protective Gloves:
Polyvinyl alcohol, nitrile rubber, or neoprene gloves are recommended to prevent skin contact.

Other Protective Equipment:
Under normal application conditions, protective glasses, gloves, and clothing are adequate.

Ventilation:
Provide adequate ventilation to maintain airborne concentrations below OSHA PELs.


SECTION 9 - SPECIAL PRECAUTIONS OR OTHER COMMENTS

Storage/Handling:
Store in cool, dry, well ventilated facility.  Store and use away from all sources of sparks, direct heat and ignition. Keep containers closed when not in use. Vapors of this material are heavier than air and will collect in low or confined areas. Empty containers can contain explosive vapors. Bond and ground all fixed and transfer equipment.

Other Precautions:
Provide adequate ventilation and avoid prolonged or repeated contact with the skin. Wash with soap and water after contact.

Work/Hygienic Practices:
Maintain good personal hygiene practices. Wash contaminated clothing before reuse. Do not eat, drink, or smoke in work areas. Wash exposed skin before eating, drinking, smoking, or applying cosmetics.


SECTION 10 - TRANSPORTATION

Regulatory Agency:
U.S.A., DOT

Identification Number:
UN1133

Proper Shipping Name:
Adhesive

Labels Required:
Flammable Liquid

Hazard Classification:
3

Other Requirements:
None Known

Packing Group:
11

Water Garden Products Home About RUBBERALL Roofing Products Site Map Contact Us

SECTION 11 – MISCELLANEOUS INFORMATION

Additional Comments:
None

Date of Previous MSDS:
August 2000

Changes Since Previous MSDS:
Comment change in sections:  1 thru 9
Add sections: 10,11

Telephone Number for Additional Information:
(574) 293-9096


DISCLAIMER

The information contained herein is based on data considered accurate which has been obtained from other companies and organizations. However, no warranty or representation is expressed or implied that the information is accurate, complete, or representative. Water Tight Technologies, LLC. assumes no responsibility for injury to the buyer, the buyer’s employees, or any third persons if reasonable safety procedures are not followed.

Seam Tape Primer Plus 5/5
March 21, 2007

 
 
Home About RUBBERALL Roofing Products Water Garden Products Contact Us About BRITE-N-EZ BRITE-N-EZ Roofing Products Roof Coatings Site Map